Vulcan-hart STEAMERS C24GA10 ML-136022 Manuel d'utilisateur télécharger pdf (Page 13)

— 13 —

C24GA SERIES GAS CONVECTION STEAMERS

CLEANING

Disconnect the electrical

power to the machine and follow lockout /

tagout procedures before cleaning.

Cooking Compartment Drains

Keep compartment drains running freely.

Inspect compartment drains daily for

blockage. Remove any particles or debris

from the perforated strainer daily (or more

often if needed).

After cooking greasy foods or seafood, close

the doors and operate each compartment for

25 to 30 minutes to flush any residual grease

and oils down the compartment drain. Make a

solution of warm water and non-chloride

detergent and pour ½ gallon (1.9 liters) of it

down each compartment drain. Rinse by

pouring ½ gallon (1.9 liters) of hot water down

each compartment drain.

Draining Generator

To prevent malfunction of controls and

clogging, it is essential to drain the generator

every day. This will flush out any accumulated

minerals from the feed water. It will also aid in

preventing internal scale buildup which would

interfere with proper generator operation.

Failure to drain the generator every day will

void the steamer warranty. The presence of

minerals in suspension is indicated by a murky

or milky condition in the first portion of the

water drained.

The water being

drained is hot and under pressure.

Use care when cleaning or servicing

the generator.

After the generator has been in operation, turn

the unit off with the power switch located on

bottom cooking cavity to drain the generator.

The generator will drain for approximately 15

minutes, removing sediment, scale and lime

buildup in the generator.

Compartments

Wash the inside of the compartment with a

solution of warm water and non-chloride

detergent. Rinse with warm water.

Once a week, thoroughly clean the exposed

surfaces (sides, front, door and top) with a damp

cloth and polish with a clean cloth. To remove

discolorations, use a nonabrasive cleaner.

Door Gaskets

Clean the gasket sealing surface of the

compartment doors to remove food acids for

maximum gasket life. Do not use any solvents

or sharp instruments. Wash with a cloth

moistened in a solution of mild detergent and

warm water. Rinse with a fresh cloth

moistened with warm water to remove all

traces of detergent.

Wipe dry with a clean cloth. Never apply food

oils or petroleum lubricants directly to the

door gasket. Petroleum-based solvents and

lubricants will reduce gasket life.

1 2 ... 8 9 10 11 12 13 14 15 16 17 18 19 20

Commentaires sur ces manuels

Pas de commentaire